The Lemon IndexAll carsMitsubishiOutlander2004
200320051st generation
Complaints only. Too few sold to score: 18,104 in the U.S. in 2004 (sales source), under the 20,000 a fair per-car score needs. Owners filed 16 complaints in its first 3 years.
16 owner complaints, first 3 years 20–21 mpg combined, EPA
Similar cars, same year
2004 Toyota RAV4 382004 Honda CR-V 1152004 Ford Escape 51
Lemon Index: 100 = the average car, lower is better.
What breaks most on the 2004 Mitsubishi Outlander
- Rust / frame corrosion15 complaintsmostly at 135,000–147,000 miles (217,000–237,000 km)
- Ball joint / control arm9 complaints
Specific parts named in the 52 owner complaints filed with NHTSA for the 2004 Mitsubishi Outlander (all dates). Miles = the odometer owners typed in (middle half); cost = the repair bills owners wrote in those same complaints, in U.S. dollars. Owners' reports, not confirmed defects.
When problems show up
Only 13 complaints listed a mileage: too few to say when problems show up.
Questions to ask the seller
- Were recalls 16V458000 (suspension), 04V428000 (equipment) and 04V197000 (trailer hitches) done? It has 4 recalls in all. Ask for the dealer printout, or check the VIN.
- Any clunks over bumps or uneven tire wear? Were struts, shocks or control arms replaced?
- Any steering noise, wander or power-steering warning? Has the steering rack or pump been replaced?
- Any oil burning, leaks or check-engine lights? Ask for oil-change records.
- Mitsubishi sent dealers 56 repair notes for this car. Was this one done: “Suspension noises after strut installation”?
From this year's own recalls, top problems, top repair bills and Mitsubishi's repair notes. Recall repairs are free at any dealer.
How serious. Out of all 16 owner complaints filed so far (every year since it was sold, not just the first 3), owners reported:
“Average car” = what the same number of complaints would include at the rate across every model year we track. Owners report these themselves; NHTSA doesn't confirm the cause.
What owners complain about most. From owner complaints to the government.
Share of this year's owner complaints filed with NHTSA, not the share of cars that break. One complaint can name more than one area.
Check engine light on? Look up any code →
When owners reported problems. From owner complaints to the government.
Most owners who filed a complaint with NHTSA had 0K to 34K miles (1K to 55K km) on the car (13 of all 16 complaints filed so far listed the miles). This shows when people who had a problem reported it, not the odds that your car will have it.
In owners' words
Consumer complained about a steering problem. The steering is pulling to the right.
2004 Mitsubishi Outlander owner · NHTSA complaint 10074061
More owner reports
When driving in the snow, the consumer lost power steering, which made it difficult to control the vehicle. The consumer contacted the dealer, however the dealer could not duplicate the problem.
NHTSA complaint 10057458
Problems Mitsubishi told dealers about
Mitsubishi sent dealers 56 repair notes for this car. The ones about its biggest problems:
- Suspension noises after strut installation
- Suspension noises
- This Technical Service Bulletin was sent to dealers informing them a shock absorber oil leak…
Ask a seller or mechanic if these were done. Some are free under warranty or a special program.
Recalls 4
- Suspension · recall issued 2016
In the affected vehicles, the front lower control arms may detach due to the front cross me.
- Equipment · recall issued 2004
CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE …
- Trailer hitches · recall issued 2004
CERTAIN SPORT UTILITY VEHICLES MAY HAVE BEEN EQUIPPED WITH DEALER-INSTALLED TRAILER HITCH WIRING HARNESS AND CONTROL MODULE.
Show all 4 recalls
- Visibility · recall issued 2003
ON CERTAIN SPORT UTILITY VEHICLES LOCATED IN THE CARIBBEAN, DUE TO A SOFTWARE PROGRAMMING ERROR IN THE ELECTRONIC TIMING AND CONTROL SYSTEM (ETACS), WHILE USING THE INTERMITTENT WIPER MODE, THE INTERMITTENT WIPER SWEEP T…
Recall repairs are free at any dealer. A recall only matters if it's still open on that exact car, so check its VIN.
Canada? See recalls at Transport Canada
Every Mitsubishi Outlander recall, all years · All Mitsubishi recalls
Safety
Crash stars (older test): front ★★★★☆ · side ★★★★★ · rollover —
Fuel cost and engines
About $2,850–$3,000 (USD) a year in fuel (EPA estimate at U.S. prices, 15,000 miles or 24,000 km a year). Engines: 2.4L 4-cyl.
Every Mitsubishi Outlander year. 2004 is highlighted. Lower is better.
Newest year first. Red = worse than average, gray = about average, too new (2023+: a partial score, marked “partial”) or too few complaints to score.
Embed this chart
Put this chart on your site, blog or forum. Free, with the credit line built in; the 2004 bar is highlighted.
<iframe src="https://lemonindex.com/embed/cars/mitsubishi-outlander/?y=2004" title="Mitsubishi Outlander reliability by model year (The Lemon Index)" width="100%" height="445" style="border:0;max-width:720px" loading="lazy"></iframe><p style="font-size:13px;margin:4px 0 0">Data: <a href="https://lemonindex.com/cars/mitsubishi-outlander/2004/">Lemon Index</a> (2004 Mitsubishi Outlander reliability)</p>Quick answers
Is the 2004 Mitsubishi Outlander reliable?
We can't score it: only 18,104 were sold in the U.S. in 2004 (calendar-year sales), under the 20,000 we need for a fair per-car score. Owners filed 16 complaints with NHTSA in its first 3 years.
What are the most common 2004 Mitsubishi Outlander problems?
In owner complaints to the government, the parts named most are suspension (25%), steering (25%) and engine (25%). That is the share of complaints, not the share of cars that break.
How many recalls does the 2004 Mitsubishi Outlander have?
4 safety recalls (latest: suspension). Recall repairs are free at any dealer; check a specific car's VIN at nhtsa.gov/recalls.
What gas mileage does the 2004 Mitsubishi Outlander get?
20 to 21 mpg combined, depending on the engine (EPA estimate).
Does the 2004 Mitsubishi Outlander have transmission problems?
Transmission and drivetrain issues make up 19% of its owner complaints.
How much does the 2004 Mitsubishi Outlander cost in fuel a year?
About $2,850 to $3,000 a year, by the EPA's current estimate.
What engines does the 2004 Mitsubishi Outlander have?
2.4L 4-cyl.
What Mitsubishi Outlander year is better than the 2004?
Nearby, the 2003 drew fewer owner complaints per car sold (about average). Across every year, 2020 drew the fewest.
The Lemon Index counts owner complaints filed with the U.S. government (NHTSA) in a car's first 3 years, per car sold, against the average car of the same model years (100 = average, lower is better). It measures complaints, not crash safety. A complaint is an owner's report, not a confirmed defect. How it works